|
|||||||||||||||||||||||||
英國GRIMM格林進口衛生級隔膜泵 UK GRIMMImported sanitary grade diaphragm pump
英國GRIMM格林進口衛生級隔膜泵概述：
進口衛生級隔膜泵亦稱衛生級氣動隔膜泵，除了具有普通隔膜泵無密封、防爆、低剪切、易維修、允許空轉、輕便、自吸啟動等優點外，更是兼具優異的衛生性能，能滿足食品、飲料、制藥等高衛生等級作業要求。
英國GRIMM格林進口衛生級隔膜泵工作原理：
1、壓縮空氣為動力。
2、是一種由膜片往復變形造成容積變化的容積泵，其工作原理近似于柱塞泵，由于隔膜泵工作原理的特點，因此隔膜泵具有以下特點：
⑴隔膜泵不會過熱：壓縮空氣作動力，在排氣時是一個膨脹吸熱的過程，氣動泵工作時溫度是降低的，無有害氣體排出。
⑵隔膜泵不會產生電火花：氣動隔膜泵不用電力作動力，接地后又防止了靜電火花。
⑶隔膜泵可以通過含顆粒液體：因為容積式工作且進口為球閥，所以不容易被堵。
英國GRIMM格林進口衛生級隔膜泵性能特點：
1、無需灌引水。吸程高達5m，揚程達70m，出口壓力≥7bar。
2、流動寬敞，通過性能好。允許通過最大顆粒直徑達6mm。抽送帶顆粒、雜質的液體時，對泵磨損甚微。
3、揚程、流量可通過氣閥開度實現無級調節(氣壓調節在1～7bar之間)。
4、氣動衛生泵無旋轉部件，沒有軸封，隔膜把抽送的介質與泵的運動部件、工件介質完全隔開，所輸送的介質不會向外泄漏。
5、不必用電。在易燃、易爆場所使用安全可靠。
6、清洗方便、過流部分無死角，進出料卡箍接口拆卸方便，環保干凈衛生。
7、使用方便、工作可靠、開停只需簡單地打開和關閉氣體閥門。即使由于意外情況而長時間無介質運行或突然停機泵也不會因此而損壞。一旦超負荷，泵會自動停機，具有自我保護性能，當負荷恢復正常后，又能自動啟動運行。
8、結構簡單、易損件少，該泵結構簡單，安裝、維修方便，液體與氣閥室部位完全隔開不接觸。
9、可輸送較粘的液體(粘度在1萬厘泊以下)。
10、不銹鋼衛生泵無須用油潤滑，即使空轉。對泵也無任何影響，這是該泵最大特點。
英國GRIMM格林進口衛生級隔膜泵技術參數：
最大流量：18.9-1042L/min
最大揚程：70m
最大吸程：3-7.6m
出口壓力：0.84MPa
口 徑：10-125mm
入氣口徑：1/4、1/2、3/4
顆粒直徑：1.5-9.4mm
英國GRIMM格林進口衛生級隔膜泵主要用途：
食品：果醬、花生醬、奶油、餡料、面糊、調味料、火鍋底料。
飲料：果汁、牛奶、果粒、糖漿、蜂蜜，
制藥：藥液、試劑、原漿、藥渣。
日化：硅油、乳化劑、香精、乳霜、表面活性劑。
酒類：紅酒、白酒、黃酒、啤酒、雞尾酒。
UK GRIMMImported sanitary grade diaphragm pumpsummary:
Sanitary diaphragm pump or sanitary pneumatic diaphragm pump, diaphragm pump is common but no sealing, explosion proof, low shear, easy maintenance, allow idling, light and advantages of self suction start, it is with excellent health performance, can meet the food, beverage, pharmaceutical and other high grade health requirements.
UK GRIMMImported sanitary grade diaphragm pumpworking principle:
1. Compressed air as the driving force.
2. Is a diaphragm reciprocating deformation caused by volume changes in the displacement pump, its working principle similar to the plunger pump, because of the diaphragm pump working principle of the characteristics, so diaphragm pump has the following characteristics:
The diaphragm pump does not overheat: Powered by compressed air in the exhaust is an endothermic process of expansion, the pneumatic pump when the temperature is lower, no harmful gas emissions.
The diaphragm pump does not produce spark: pneumatic diaphragm pumps do not have electricity for power, ground and later to prevent electrostatic spark.
The diaphragm pump liquid containing particles can be: because the volume of imports and working for the ball, so can not be easily blocked.
UK GRIMMImported sanitary grade diaphragm pumpperformance characteristics:
1. No water diversion. Suction lift up to 5m, the head of 70m, the outlet pressure is greater than or equal to 7bar.
2. Flow spacious, through good performance. The maximum particle diameter is allowed up to 6mm. Pumping liquid with particles, impurities, little wear on the pump.
3. Head, flow can be achieved through the opening of the valve stepless adjustment (air pressure between 1 ~ 7bar).
4. Pneumatic sanitary pump with no moving parts, no moving parts, seal, diaphragm pumping medium and pump completely separated from the workpiece medium, the transmission medium does not leak out.
5. Do not use electricity. It is safe and reliable for use in flammable and explosive places.
6. The cleaning is convenient, the flow part has no dead angle, the material inlet and outlet clamp interface is convenient to disassemble, and the utility model has the advantages of environmental protection, cleanness and sanitation.
7. Easy to use, reliable work, open and stop, simply open and close the gas valve. The pump will not be damaged even if the medium is not running for a long time due to an accident. Once overload, the pump will stop automatically, with self-protection performance, when the load has returned to normal, but also automatically start operation.
8. The utility model has the advantages of simple structure and less wearing parts, the structure of the pump is simple, the installation and the maintenance are convenient, and the liquid is completely separated from the valve chamber part without contact.
9. Can carry more viscous liquid (viscosity at below 10 thousand CPS).
10. Stainless steel sanitary pump, no oil lubrication, even idling. No effect on the pump, which is the biggest feature of the pump.
UK GRIMMImported sanitary grade diaphragm pumptechnical parameter:
Maximum flow: 18.9-1042L/min
Maximum lift: 70m
Maximum suction range: 3-7.6m
Outlet pressure: 0.84MPa
Caliber: 10-125mm
Inlet caliber: 1/4, 1/2, 3/4
Particle diameter: 1.5-9.4mm
UK GRIMMImported sanitary grade diaphragm pumpmain use:
Food: jam, peanut butter, cream, stuffing, batter, seasoning, pot base.
Drinks: fruit juice, milk, fruit granules, syrup, honey,
Pharmacy: liquid medicine, reagent, raw liquid, dregs.
Daily chemicals: silicone oil, emulsifier, essence, cream, surfactant.
Wine: red wine, white wine, yellow rice wine, beer, cocktail.
